low pressure horizontal gas fired steam boiler

Gas boiler SZS, WNS, F, A, L, N, B and other parameters have what meaning? SZS gas boiler water is commonly used parameters. Wherein the meaning of each letter, S: double drum. There are two drum boiler, goes under the distribution structure. Z: vertical type. Using the "D" type arrangement, arranged longitudinally down drum, as the flue gas flow partition Wall full mode, the left side of the boiler convective tube bank is arranged. S: combustion chamber. Fuel is powdered (solid fuel, such as coal), mist (liquid fuels, such as oil), gaseous (gaseous fuel, such as natural gas) along with the air into the furnace (combustion) combustion in suspension. WNS is automatic gas (oil) parameters commonly used boiler. In which the meaning of each letter, W: horizontal. A boiler according to the design and installation of the outer layout, was lying state. An exhaust gas stream produced by the boiler is of horizontal flow, the flow of hot gas, in the same section on the exhaust gas temperature is low compete. N: internal combustion. After all of the fuel combustion flue gas, without burning the residue was heated with a heating surface directly mixed working fluid (water), and the flue gas, steam as the working fluid work output, the flame in the combustion furnace through the center of the drum. S: combustion chamber. Fuel is powdered (solid fuel, such as coal), mist (liquid fuels, such as oil), gaseous (gaseous fuel, such as natural gas) along with the air into the furnace (combustion) combustion in suspension. F: split. A: three return. N: N is low. L: condensation. B: Center backdraft.

Hot water boiler which is not equipped with no impact can cause demineralizer 1, the waste fuel boiler fouling occurs, resulting in poor heat transfer performance of heating surface, so that heat generated by the combustion of the fuel can not be timely delivered to the boiler water, but a large amount of heat is smoke away, resulting in exhaust gas temperature is too high, if the exhaust gas loss increases the thermal efficiency of the boiler will be reduced. In order to maintain the nominal parameters of the boiler, fuel must be increased, thereby wasting fuel. About 1 millimeter scale waste fuel ten percent. 2, the heat receiving surface is damaged due to deterioration of the heat transfer performance, fuel combustion heat is not quickly transmitted to the boiler water, resulting in the furnace and the flue gas temperature. Thus, the temperature difference on both sides of the heating surface increases, the metal wall temperature, a decrease in strength. Under pressure pot, bags and even blasting will occur. 3. Reduce heat boiler output due to the deterioration of the performance of boilers, need to consume more fuel to reach the nominal rate of evaporation. However, with the increase in the scale thickness, the volume of the furnace becomes large, the fuel consumption is limited. Therefore, it is possible to reduce the output of the boiler. 4, the corrosion damage to the metal: oxygen in the water, acid, base materials will corrode the metal surface of the boiler, it is thinned, recess or perforation, thus reducing the power of the boiler, seriously affect the safe operation of the boiler. 5, in addition to improper operation Priming outside, when the boiler water contains more sodium chloride, sodium phosphate, and silicides oil, boiling or evaporation process boiler water, boiler water occurs when soap and organic base when Teng because soda will produce compost. Foam liquid surface, formed soda pool. No softening, easily scalable. Due to the continuous evaporation steam, boiler of calcium, magnesium, high impurity concentration is 30-50 times that of natural water, fouling rate beyond our imagination, only six months to a year, from 1-2 mm.

Such as hotel Home Hotel Group is one of the three major brands, in 300 cities in the country has nearly 2,000 hotels. Home Inns has won China Golden Pillow Award for Best Chinese economy hotel chain brand award, in 2014, Home Inns brand value of $ 420 million of selected China's top 100 brands. April 4, 2016, BTG hotel groups such as the privatization of the hotel purchase transaction has been completed delivery. In mid-2016, as a Beijing hotel with our preliminary communication, the urgent need two boilers work of heating and hot water supply. I related technical engineers and recommend it to calculate the number and size of the boiler on the hotel room as hotel Willy sharp V6-99 two models.

Gas boiler precautions required during installation methods, or steps :( a) a foundation base of the boiler should be provided is determined according to the local soil, manufacturers design reference by the civil sector again. After reaching the base strength boiler, the boiler should drawings inspection and acceptance, and to draw the whole boiler three reference lines: a, longitudinal reference line - drum center or the center of the combustion apparatus. b, lateral reference line - the center of the front axle or chain grate slag centerline of the machine. C, elevation reference line - can be selected from a number of locations about four weeks, respectively, on the basis of the marking, the relative offset between the markers should not exceed 1mm. Furnace in place. After assembly the lower part of the boiler in place first, then the upper assembly large, the upper and lower portions need to find a combination of two positive pads firmly, should be both inside and outside the two casting. Installation location and size deviation test methods according to GB50273 "boiler installation engineering construction and acceptance" implementation. (B) lifting the boiler, during lifting, should be suspended on a lifting lug drum boiler ready large, the boiler on a foundation base coincides with the pre-drawn reference line. The longitudinal centerline of the boiler and the foundation, the deviation is not more than 3 mm, and the inclination with the center line of the drum hammer correction, allowing the central drum inclination is not larger than 5 mm, otherwise use horns foundation base and the junction pad level. Maximum level (c) Installation of boiler network (1), water supply conduit installation requirements typically require as backup pool below the normal water level line of the boiler, so as not to shutdown, boiler feedwater flowing into a large number of drainage caused to start the next . At the outlet of the tank (i.e., an inlet feed line) should be installed wire screen. (2), a main steam line installation requires the main steam lead pipe straight run section should be more than 0.5 m, the bending radius should be 4-5 times the diameter of the pipe, the trap should be fitted at the lowest line in order to prevent water hammer pipe, while to be reliable insulation. (3), the safety valve should be installed in the valve installation requirements after the hydrostatic test, the safety valve shall be fitted exhaust pipe, the exhaust pipe of the safety guide outside the boiler house, allowed valving the exhaust pipe. (4), mounting a lower water table level table downcomer must access a safe place, Hancock rotating flexible water table, not leaking, water table must be installed to the lighting device, easy to observe. (5), a pressure gauge mounting means so that when the scale gauge vertical plates, should be painted red gauge scale to show the maximum allowable pressure boiler, rotating flexible plug gauge, not leaking, water flow, pressure gauges insulation prohibited. (Iv) the boiler chimney installation requirements, when lifting the chimney, the chimney should be straight, horizontal direction lead length should not be too long, generally less than 5 meters, the height of the chimney should comply with relevant national standards. To add chimney rain cap, the weight of the chimney should not fall directly on the boiler chimney take over the host. Installation (e) combustion system: 1, according to the combustion system of FIG power line control circuit, a control signal line and the control line is electrically connected, the program should be installed reliable ignition and flame failure protection devices. Combustion process controller provides a separate set of contact start-stop control. May be formulated in a variety of burner start-stop loop cascade control relay 10A is a fuse, relay start-stop control stops the control terminal may be connected to the burner, may directly control the power of the burner. Both constant pressure sensor, water power, fuel, gas pressure set value is detected after the automatic controller opens. Time pressure sensor, water supply, oil, gas, and their detection circuit, alarm and found the problem immediately shutdown flame protection, the controller automatically displays the point of failure, an alarm sounds machine.

low pressure horizontal gas fired steam boiler Related Information

Gas & Steam Boiler

2020-3-14 · Characteristics about the boiler: 1.Fuel:Natural gas,LPG,CNG,LNG,diesel oil,heavy oil,city gas,dual fuel,etc. 2.The steam boiler have horizontal structure,so the thermal efficiency is higher; 3.It has the three returns design, so exhausted smoke temperature is low;

Get a Quote

Steam Boiler, Thermal Oil Boiler - Alibaba.com

Qingdao East Power Industry Equipment Co., Ltd., Experts in Manufacturing and Exporting Steam Boiler, Thermal Oil Boiler and 647 more Products. A Verified CN Gold Supplier on Alibaba.com.

Get a Quote

Horizontal atmospheric pressure Oil and gas fired hot

2019-3-20 · Horizontal atmospheric pressure hot water boiler has a compact structure, safe and reliable, simple operation, rapid installation, low pollution, low noise, high efficiency, etc, are widely used in enterprises, hotels, hospitals, office buildings, civil construction facilities such as industrial and heating steam and life.And especially gas hot

Get a Quote

vertical steam boiler zg industry boiler

2018-7-19 · Vertical Steam Boiler, Vertical Steam Boiler Suppliers and Alibaba.com offers 9,208 vertical steam boiler products. About 100% of these are boilers. A wide variety of vertical steam boiler options are available to you, such as natural circulation, once through. Standard Steam

Get a Quote

industrial low pressure heating boiler

industrial low pressure heating boiler - flexonics.au. High Pressure Steam Boiler VS Low Pressure Steam Boiler . Low pressure steam boiler are used for generating heat for industrial use or for heating systems found in healthcare facilities, apartments, universities, office buildings and historic landmark building.

Get a Quote

low pressure horizontal water boiler supplier

China Low Pressure Steam Boiler, Low Pressure Steam . 2010-6-8 · If you are interested in China Low Pressure Steam Boiler, You will be amazed by the variety of the product choices such as steam boiler, boiler, hot water boiler. Besides, their competitive & cheap price of Low Pressure Steam Boiler factory would get you an edge in your own market.

Get a Quote

Gas Fired Steam Boiler,Horizontal Steam Boiler,Gas

Horizontal Gas Fired Steam Boilers. DEVOTION WNS series Gas Steam Boilers are internally fired, three-pass and wet back shell boilers. Rated output(ton/hour): 0.5,1,2,3,4,5,6,8,10,15,20 Customer tailored design is available.

Get a Quote

Gas Fired Steam Boiler on sales - Quality Gas Fired

6000 Kg Low Pressure Horizontal Gas Fired Steam Boiler For Brewery Easy Maintenance 1. Our 6000kg Gas Fired Steam Boiler is a horizontal three-return full-wet back steam boiler with a capacity of 6 t/h.

Get a Quote

low pressure horizontal gas fired thermal oil boiler

horizontal low pressure boiler - emahospitality.c. horizontal low pressure steam boiler. Our company's main products include gas&oil-fired boiler, coal-fired boiler, biomass boiler, thermal fluid heater and other series with more than 400 varieties of specifications. ZOZEN boiler covers an area of 150 thousand square meters, with an annual.

Get a Quote

Low Price Biomass Fired Horizontal Steam Boiler

low price rice husk fired steam boiler Industrial Boil. Steam Boiler Machine, Steam Boiler Machine Suppliers and Manufacturers Steam Boiler Machine, Wholesale Various High Quality Steam Boiler Machine Products from Global Steam Boiler Find Complete Details about gas fired boiler,oil fired boiler,oil steam boiler from Supplier or Manufacturer on Alibaba.com high pressure, or low pressure.

Get a Quote

Chinese Hot Sale Oil Gas fired Horizontal Low

Steam Boiler Founded on January 8, 1998, the company has a registered capital of more than 100 million yuan. It is a high-tech enterprise integrating R&D, manufacturing and sales of clean fuel boilers and clean combustion technology boilers.

Get a Quote

Gas & Steam Boiler

2020-3-14 · Characteristics about the boiler: 1.Fuel:Natural gas,LPG,CNG,LNG,diesel oil,heavy oil,city gas,dual fuel,etc. 2.The steam boiler have horizontal structure,so the thermal efficiency is higher; 3.It has the three returns design, so exhausted smoke temperature is low;

Get a Quote

Annual Low Pressure Boiler Inspection Review List

2019-9-2 · required for a single low pressure steam boiler having an output of 350 mBtuh or less. MC 1005.1 Flanges are ac-cepted in lieu of valves for a single low pressure steam boiler. If possible, inspect combustion chamber for missing or damaged refractory. Bottom blow off valves are required to be connected to the lowest water space possible.

Get a Quote

low pressure vertical steam boiler - asc-westfalen

Low Pressure Steam System L.E.S Boilers Horizontal Low pressure steam boiler, 83% efficient Duplex boiler feed system Twin alternating water softener Blowdown separator with cooling package Single point connection for utilities: Natural gas, Water, Steam, Drain, Exhaust, Vent

Get a Quote

Steam boiler, electric heating steam boilers, hot water

2020-1-18 · Sitong boiler manufacture and export variety industrial boilers, various fuels can be fired, coal biomass oil gas steam and hot water boilers, thermal oil boiler and electric steam boiler

Get a Quote

Related Information

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top