gas fired steam generator made in china

Guangdong Provincial Quality and Technical Supervision regarding the development of biomass briquette boilers special work

Recently, Guangdong Province issued "Notice on biomass briquette boilers special work" (the "Notice"), requiring the province since the beginning of July biomass briquette boilers carpet Mocha by three months the complete list of developed and complete the scattered dirt biomass boilers in the province before the end of 2019, direct combustion, such as non-compliance out of chaos and rectification.

First, remediation objects

According to "People's Republic of China Air Pollution Prevention Law" and "Guangdong process boilers pollution remediation plan (2016-2018 years)", (Guangdong ring [2016] No. 12), this special work-out and the quality of the main targets include: direct burning biomass boiler, the boiler does not meet the high-pollution fuel combustion zone ban management requirements, central heating boilers dispersed within the heating network coverage, the boiler gas pipeline network coverage, the use of coal and its products the dual-fuel or multi-fuel biomass fired boiler, coal-fired boiler into a biomass briquette boilers do not meet the legal reform program, it has been approved by the people's government the right to shut down the boiler and other companies.

Second, the remediation measures

(A) strengthen the management of biomass briquette boiler

New boilers should biomass briquette Briquette dedicated biomass boilers (or dual-fuel fuel designs allowed). For the latter meet the conditions for registration of quality supervision departments also must apply for environmental procedures according to law, be put into use.

(B) strictly regulated pollutants raw material is fired boiler

Environmental protection departments should strengthen supervision of pollutant emission biomass-fired boilers molding, organize supervision and monitoring of the discharge port of inspection car, pollutant emission concentration of biomass fired boiler to reach or better than the current corresponding to the natural gas boiler emissions standard (conversion 9% oxygen content reference emission concentration), the concentration of carbon monoxide emissions of less than equal to 200 mg / cubic meter, the feed inlet video surveillance facilities biomass fired boiler is to be networked and environmental protection sector, more than 20 tons of steam biomass molded fuel boiler to be installed on-line monitoring equipment, and networking with the environmental protection departments to encourage 20 tons of steam biomass fired boiler to install online monitoring equipment. For pollutant emissions are out or do not meet the requirements dealt with by the environmental protection department according to the law, the quality supervision department cooperate with law scrapped boiler, write-offs.

Third, the time node

"Notice" announced the schedule for the remediation activities: biomass briquette boiler before June carding meet the special requirements of the boiler, the development of monitoring plans by the local environmental protection department, by supervisory monitoring, enterprise self-monitoring measures to ensure that in 2018 exhaust gas monitoring complete biomass fired boiler is in the list before the end of the boiler to investigate and punish excessive emissions.

7 to 10 months focusing on remediation biomass briquette boilers do not meet the special requirements of the boiler. Since August, the quality supervision departments throughout the province last month to the cancellation of the 5th of each month, scrap, corrective actions and a list of biomass briquette boiler re-enable the exchange to the same level of environmental protection department, the environmental protection department of the list with boiler organizations atmospheric monitoring pollutants.

In addition, quality inspection departments to be before the end of 2018, before the end of 62,019 years to complete before the end of October 2019 were 30%, 70%, to urge the rectification work 100% of the boiler problem.

After you have a list of remediation raw material briquette boilers, by supervisory monitoring, self-monitoring and other measures to organize corporate environmental protection departments in the country to receive quality supervision departments to provide complete exhaust gas monitoring within two months, to ensure that all students complete before the end of 2019 material fired boiler emissions monitoring.

Fourth, the work requirements

(A) submit the required work ledger

Listing biomass briquette boilers local quality supervision departments to the end of June 2018, is currently in line with energy-saving features of the device and safety requirements submitted to the Provincial Quality Supervision Bureau, the Provincial Quality Supervision Bureau to exchange Provincial Environmental Protection Office. The second half of 2018 --2019 end of each quarter, the environmental protection departments throughout the progress of work on the 5th an accumulation of sound required to submit the Environmental Protection Agency.

(B) a comprehensive inventory, leaving

To work closely local quality supervision departments and environmental protection departments, clear name and contact details, according to "local management, levels of responsibility, seamless, comprehensive coverage of" principle, carpet-Mocha, timely updated sound biomass briquette boiler list, the implementation of ledger-style, pin number management. A complete rectification, a pin number.

(C) strict law enforcement, supervision of implementation

Local quality supervision departments and environmental protection departments according to their respective functions, like take the time node, according to the law to carry out renovation work on the investigation, to ban the work may not be implemented, to promote the progress has lagged far behind, regulatory serious dereliction of duty, serious accountability related personnel responsibility. Provincial Environmental Protection Bureau, Quality Supervision Bureau will form a joint inspection teams fired boiler renovation work carried out around the biomass conduct spot checks, reporting the progress of work.

Overall, the Guangdong Province to seize the chaos veered to burn biomass briquette industry in recent years in existence, the name of biomass, coal and other solid chaos, both for air pollution control pollution, but also conducive to purifying biomass briquettes industry ecosystem, promote the healthy development of the industry norm.

Electric heating steam boiler replacement can be significant savings in annual electricity consumption: have had experience in chemical production people know, the vessel was heated power consumption has been the largest chemical production point system, whether as an entry point to reduce costs, is long plagued the problem of chemical industry. After a long period of research and at the same time, it was discovered that the use of steam boilers, chemical production can reduce costs radically. The original electric heating reactor to complete the fired steam generator made in china heating steam, both to meet the needs of the production process, but also reduces the cost of power consumption. Electric heating steam boiler replacement can significantly save electricity each year. Reactor apparatus as used in modern industry, widely used in food processing, pharmaceutical production, dye processing, petrochemical industry, rubber, pesticide manufacturing and other industries.

Works steam boiler steam boiler structural characteristics: 1. Heat generated in combustion of coal is first absorbed water wall heat transfer by radiation, boiling off the water wall, a large amount of steam (excluding DC furnace) inside the drum, separated saturated steam enters the superheater, and by radiation and convection manner continue to absorb top horizontal flue heat and smoke flue tail, the superheated steam to reach the required operating temperature. Steam boilers for power generation is usually provided with a reheater, to a high pressure steam heated cylinders. Reheat steam reheaters into the low-pressure cylinder continue to work to generate electricity. 2. pulverized coal work, the location of the center of the flame will affect evaporation. Generally, when the center of the flame is low, a large amount of evaporation, and when the high center of the flame, a small amount of evaporation. Also affects the position of the center of the flame superheated steam or reheat steam temperature. Normally, when the center of the flame is low, superheated steam, in particular steam reheating temperature to be low, and the temperature of the superheated steam is high. 3. Pulverized Coal Burner front and rear walls is arranged a thrust manner, tangential firing mode, bis tangential firing methods, each method has its own characteristics. Biomass boiler is a kind of boiler to biomass energy as a boiler fuel called biomass boilers, steam boilers into biomass, biomass hot water boiler, biomass stove, biomass thermal oil heaters, vertical raw biomass boilers, biomass boilers and other horizontal. Since the above-described arrangement can not be applied in the same furnace at the same time, the influence of steam can not be directly determined. Steam boiler structural characteristics: 1, the steam boiler body welding: the main welding using submerged arc welding technology advanced, to ensure the welding quality. There are heating and hot water boiler bath for two purposes. Hot water boiler by circulating hot water circulation pump hot water holding tank, the tank hot water heating cycle can be achieved bath object; hot water boiler by circulating hot water circulation pump heating conduit, through the heat sink (radiator) people can achieve heating requirements; hot water boiler and hot water circulating pump with heat exchanger can be achieved bathing and heating dual function. All welds are main as required "safety Technology supervision standard", 100% ray detection electrode according to the eligibility criteria Ⅱ. 2 is a horizontal steam boiler combustion all wet back three-loop structure. 3. The steam boiler front smoke box is sealed asbestos refractory material made of graphite. The reliable seal, ensures that no leakage of steam boiler flue gas at positive pressure conditions. 4. Thread flue: fired steam generator made in china secondary regenerator flue threaded convection heating surface, contribute to the efficient heat transfer. Enhanced heat transfer, thermal efficiency of the steam boiler, a single light pipe threaded pipe or 2.4. When the fluid flows in the tube, the flow rate of the fluid near the wall is low, the fluid on the wall boundary layer is called. In several of the flue gas duct in the outer aqueous series resistance, the maximum thermal boundary layer, but the boundary layer is very thin, as long as the boundary layer is slightly perturbed, such as by pressing on a common wall of the boss, the thermal resistance will be greatly reduced, while an effective method which is threaded pipe. 5. To make the system more energy efficient, using a continuously adjustable water supply, avoiding frequent start the pump. Between the second and the third pivot smoke tubes have a broad space for water, in order to ensure natural circulation of water in the pot.

The main purpose of the boiler is the main purpose of what the boiler: Boiler national economy is an important energy supply equipment. Electrical, mechanical, metallurgical, chemical, textile, paper, food and other industries, as well as industrial and civil heating boiler needs to supply large amounts of heat. Boilers using fuel combustion energy released or other energy to the working fluid (heat carrier intermediate) is heated to a certain device parameters. For heating the water to make it into the boiler steam is known as steam boilers, also known as a fired steam generator made in china for heating water to make them more water into the boiler temperature, known as the hot water boiler for heating of Heat Transfer Fluid It called boiler organic heat carrier boiler.

gas fired steam generator made in china Related Information

China Small Steam Boiler Generating Electricity Photos

Steam Boiler Generating Electricity, Electric Boiler Generating Electricity, Steam Generator Generating Electricity manufacturer / supplier in China, offering Small Steam Boiler Generating Electricity, 2016 Hot Sale Oil (Gas) Fired Steam Boiler for Food Service Industries Boilers, Ce Certified 800kg/H Oil Fired Steam Generator and so on.

Get a Quote

China 150kg/Hr Automatic Wood Pellet Steam Boiler -

Automatic Wood Pellet Boiler, Pellet Steam Boiler, Pellet Steam Generator manufacturer / supplier in China, offering 150kg/Hr Automatic Wood Pellet Steam Boiler, Horizontal Single-Drum Industrial Coal Fired Steam Boiler, Fuel Gas, Diesel, Heavy Oil Steam Boiler and so on.

Get a Quote

China Boiler manufacturer, Steam Boiler, Industry

China Boiler supplier, Steam Boiler, Industry Boiler Manufacturers/ Suppliers - Qingdao East Power Industry Equipment Co., Ltd.

Get a Quote

China Boiler manufacturer, Steam Boiler, Oil Boiler

China Boiler supplier, Steam Boiler, Oil Boiler Manufacturers/ Suppliers - Prefly Thermal Technology Co., Limited

Get a Quote

China 500kg Biomass Steam Generator for Industrial

Stem Boiler, Steam Generator, Wood Pellet Steam Generator manufacturer / supplier in China, offering 500kg Biomass Steam Generator for Industrial Use, Industrial Biomass Wood Chips, Rice Husk Fired Water-Fire Tube Steam Boiler Generator 1-4t/Hr for Food Industry, Industrial Coal, Biomass, Wood Chips Fired Steam Generator Boiler 1-4t/Hr Food Industry and so on.

Get a Quote

Steam generator Manufacturers & Suppliers, China

steam generator manufacturer/supplier, China steam generator manufacturer & factory list, find qualified Chinese steam generator manufacturers, suppliers, factories, exporters & wholesalers quickly on Made-in

Get a Quote

Boiler from China Manufacturers - China Gas Boiler

China Boiler, offered by China manufacturer & supplier -Taikang Yinyu Boiler Manufacturing Co., Ltd., page1

Get a Quote

China Boiler manufacturer, Steam Boiler, Gas Boiler

Boiler, Steam Boiler, Gas Boiler manufacturer / supplier in China, offering 10t H City Gas Steam Generating Boiler Machine for Restaurant School, Low Emission Gas-Fired Wet Back Firetube Hot Water Boiler, 20t/H Industrial High Efficiency Low Emissions Gas Steam Boiler and so on.

Get a Quote

All Products - Made-in-China.com

China Output: hot water (Power: Electricity), Output: hot water (Power: Oil/gas), output:steam(power:Electricity), offered by China manufacturer & supplier -Shanghai

Get a Quote

China Boiler manufacturer, Steam Boiler, Gas Boiler

Boiler, Steam Boiler, Gas Boiler manufacturer / supplier in China, offering 10t H City Gas Steam Generating Boiler Machine for Restaurant School, Low Emission Gas-Fired Wet Back Firetube Hot Water Boiler, 20t/H Industrial High Efficiency Low Emissions Gas Steam Boiler and so on.

Get a Quote

autoclave, gas/oil fired steam boiler from China

Boiler, Steam Boiler, Steam Generator manufacturer / supplier in China, offering Super Low Temperature Air Source Heat Pump, Factory Price Automatic Steam Heating Industrial Autoclave, Energy Saving and Clean 2000kg/Hr Electric Steam Boiler and so on.

Get a Quote

autoclave, gas/oil fired steam boiler from China

Boiler, Steam Boiler, Steam Generator manufacturer / supplier in China, offering Super Low Temperature Air Source Heat Pump, Factory Price Automatic Steam Heating Industrial Autoclave, Energy Saving and Clean 2000kg/Hr Electric Steam Boiler and so on.

Get a Quote

Steam Generator manufacturers & suppliers - Made

China Steam Generator manufacturers - Select 2020 high quality Steam Generator products in best price from certified Chinese Electric Generator manufacturers, China Generator suppliers, wholesalers and factory on Made-in-China.com

Get a Quote

China Rated Steam Capacity 300kg/H Gas Fired Steam

Boiler, Steam Boiler, Gas Fired Steam Boiler manufacturer / supplier in China, offering Rated Steam Capacity 300kg/H Gas Fired Steam Generator, Industrial Biomass Wood Chips, Rice Husk Fired Water-Fire Tube Steam Boiler Generator 1-4t/Hr for Food Industry, Industrial Coal, Biomass, Wood Chips Fired Steam Generator Boiler 1-4t/Hr Food Industry and so on.

Get a Quote

Steam Generator-China Steam Generator

China Steam Generator - Select 2020 Steam Generator products from verified China Steam Generator manufacturers, suppliers on Made-in-China.com.

Get a Quote

Related Information

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top