Full Automatic Fire Tube Oil Fired Steam Boiler for Heating

Circulating Fluid Boiler has high working capacity and steam pressure than chain grate boilers. So, those cfb boilers are often used in larger industry sites such as power plant, oil refines, chemical industry, glass plant, bricks factory, rubber industry, etc. Coal fired cfb boiler has stable and good performance. The project of 85 ton coal fired cfb boilers to Mongolia has started in July 2014. Our consumer in Power plant from Mongolia by airport to Zhengzhou, China, visited our factory and talked with our engineers.

1: Steam boiler steam pressure the higher the better selection pressure, depending on the user's requirements. Vapor pressure, safety pressure member Advantageously, the energy consumption is low; but the steam will be relatively worse quality, low enthalpy, humidity, may be difficult to meet the disinfection, sterilization, culture, heating and power needs. And the high vapor pressure, energy consumption is high, the corresponding steam equipment, piping and valves the pressure is high, the maintenance requirements are also more, the production of steam, the heat transfer process, a large leakage loss. Meanwhile, high-pressure steam as the steam pressure is increased to carry the increased salinity, so salinity these waterwall tubes, pipe tobacco, and other drum heating surface fouling, overheating, foaming, clogging even increase the possibility of squib. Salt steam to steam turbine flow area will decrease, reducing the efficiency and seriously affect the heat transfer. Thus, fireman must operate in accordance with operation of the steam pressure, the steam pressure fluctuations generally allows a value between 0.05 ~ 0.15MPa.

2: the higher the boiler water level was considered safe water level is higher, the boiler water is not easy, security is also guaranteed. In fact, this is a misconception, the water level is too high, steam and humidity increase, poor steam quality, steam equipment will harm and production results. Industrial boilers, a moisture vapor sterilization or incubation with a large amount of steam also increased salt, or culture for a long time ranging from sterilization, steam consumption increase, ineffective, decreased production culture; weight is not reached the purpose of disinfection or cultured biological products contaminated scrap, even pipes, water hammer occurs apparatus. For utility boilers, steam moisture capacity, the steam turbine last stage blades will be erosion, there may appear Priming pot, water shock severe enough to cause harm equipment and personal safety. Thus, the pot water level should be maintained within a fluctuation range of ± 50mm well.

3: Some people think the better fuel plus fuel plus the more productive the greater the amount of steam. Little do they know too much fuel into the furnace, the effect will be counterproductive. When a certain amount of air and the excess amount of fuel, the furnace will produce a large amount of incomplete combustion, resulting in energy waste. People often see the dark furnace flame, weakness, and black smoke chimney, mostly for this reason. In severe cases, there will be fire pulverized coal, oil furnace secondary combustion occurs, burst pipes until shutdown. Therefore, the ratio of fuel and air volume should be adjusted appropriately, typically by looking at the fire, smoke color look, see table indicates the amount of oxygen determined. When the flame in the furnace as a bright yellow, pale gray smoke chimney to take, stable vapor pressure, wind coal showed appropriate ratio, good combustion.

4: Dial stirring the fire, the better the fire is commonly used in industrial boilers manual method. By stirring the fire, can be eliminated crater, reduction furnace from the fire and the fire bed smooth, homogeneous combustion, strong. But too much stirring the fire, but will reduce the overall thermal efficiency; this is because when stirring the fire, a lot of cold air into the furnace, reducing the average temperature of the furnace section of the flame. At the same time, increase the heat losses, an increase in the number of black smoke chimney, pollution of the environment. In addition, when stirring the fire, the staff is also susceptible to flame radiation, burns, fire-resistant layer is also susceptible to dial hearth fire damaged tools, increased furnace building maintenance workload. Therefore, the fire should be allocated as needed, to minimize the appropriate dial.

5: the bigger the better furnace pressure and furnace pressure is reflected in one of the boiler combustion conditions is normal or not an important parameter. Operating the boiler furnace negative pressure should be maintained between 10 ~ 20Pa, too great a negative pressure results in: increased leakage furnace, heat losses increase; wind increased electrical energy consumption; fly ash increased the wear along the heating surface; reduced the furnace heat of combustion efficiency. Most gas-fired boiler designed to run slightly positive pressure to increase the combustion rate. Operation, the furnace pressure becomes positive, even increasing the wind is still difficult to maintain the chamber negative pressure, said system failure or the wind furnace wall tubes, superheaters and other soft drinks leakage; fire furnace, the furnace pressure is first reflected table violent swing to the negative direction flung head. Therefore, the furnace pressure must be run according to the provisions, or should pinpoint the cause.

6: sewage longer the better spoken here regularly refers only to the sewage discharge rather than continuous blowdown. Periodic sewage mainly refers to the existence of negative bottom of the boiler slag, dirt and corrosion products, reduce furnace tube fouling, prevent clogging and reduce the salt content of the water boiler, heat transfer enhancement effect. One would think that the longer the discharge time, impurities will be discharged bottom of the pot the more, the better sewage, it is not. Sewage long time, a waste of a lot of heat, affect heating steam pressure; two pairs of boiler water circulation unfavorable, water wall tube burst will occur in severe cases. Thus, the sewage must be periodically according to "ground discharge, the discharge less uniform row" principle, provided hand operation. General Provisions at least once every eight hours of sewage, sewage each time shall not exceed 30s, overtime is strictly prohibited.

Gas-fired full automatic fire tube fired steam boiler for heating safe operation Tidbits gas steam boiler safe operation Tips 1. The operator should be familiar with the structure and principles of the furnace and the production of basic requirements for thermal equipment, and constantly sum up experience in practice, control coal thickness, so that the full combustion reduce chimney smoke, protect the equipment in a safe, efficient operation. 2. The new oil furnace or restart long home, gas steam shall dehydration stage heating requirements. 3. export oil temperature should be set below 280 ℃, when the oil temperature exceeds 200 ℃, should pay more attention to temperature, oil temperature should slow down, only non-oil change and over-temperature operation. 4. close contact with production, timely and slow down the oil temperature, while meeting production requirements, taking oil lower, will help extend the life of gas and steam energy savings. The normal oil level: the lower tank oil level is low, high-high oil groove. This ensures that the emergency shutdown when cold oil replacement system and prevents air from entering the pipe. When the high slot in a low oil level should start to replenish gas steam injection pump. 6. The circulation pump is allowed outage in the operation of the burner, when the pump is failure or power outage, Fan stop, depending on oil temperature and take appropriate emergency measures: rapid opening valve 7, the cold head tank oil up through the furnace coils to the low tank. 8. Coal and wet coal hearth fire or discharge out of the furnace, non-water washed pouring furnace. These measures should be completed within 3 to 5 minutes, to prevent the high oil temperature coke deposits other accidents. 9. normal shutdown, the oil temperature should be reduced to below 100 ℃, stop the pump before. 10. When the outlet pressure differential below the set value, the induced draft fan should outage. Then there is a fault system, feedback should be immediately removed or, if necessary, should pressure fire outage. 11. fireman should stick to their posts, do a good job operating records and shift work, and regular inspection and maintenance equipment.

Directly under the Central Government Offices Administration (referred to as the straight Authority) is the CPC Central Committee and subordinate units, are responsible for the CPC Central Committee and services for the organs and services, an important function of serving the people. Central Government institutions funds, finance, public service vehicles, the state-owned assets and real estate management, service management is responsible for the specified life of the party and state leaders as well as services related objects.

Full Automatic Fire Tube Oil Fired Steam Boiler for Heating Related Information

2WY-3WY Horizontal oil-fired marine boiler-Wuxi Weilit

WY series oil fired steam boiler is horizontal two or three pass fire tube wet back full automatic steam boiler. It normally suitable for 500kg to 20ton/h capacity, use different kinds of oil fuels, such as marine gas oil, diesel oil, heavy oil.

Get a Quote

WNS Series Horizontal Fire Tube Steam

Brief Introduction of WNS Series Oil Gas Steam Boiler:. The working principle of the fire tube boiler is based on hot gases of combustion that circulates through a range of pipes surrounded by water. TaiGuo® WNS Series fast assembly fire tube gas oil fired boiler, also known as three pass design boiler or packaged boiler, is a kind of safe, eco-friendly and high efficiency heating equipment

Get a Quote

2WY-3WY Horizontal oil-fired marine boiler-Wuxi Weilit

WY series oil fired steam boiler is horizontal two or three pass fire tube wet back full automatic steam boiler. It normally suitable for 500kg to 20ton/h capacity, use different kinds of oil fuels, such as marine gas oil, diesel oil, heavy oil.

Get a Quote

full automatic gas water boiler oil fired boiler for sale

looking for full automatic heating medium boiler products from 853 full automatic heating medium boiler suppliers and full automatic heating medium boiler This paper describes the technical features of Type WNS10.5-1.0/115/70-Q2 full-automatic gas hot waterboilers developed to be suiteble for gaseous fuel.

Get a Quote

Henan Kingthai Boiler Manufacturing Co., Ltd

Kingthai WNS series gas oil steam fire tube boiler is a kind of safe and high efficiency heating equipment with full automatic control system. This series oil gas fired boiler is horizontal type fast assembly fire tube boiler with three pass structure, it has compact structure, small volume, strong load adaptability and

Get a Quote

Full Automatic 1.5 Ton Gas Oil Biogas Fired Steam

2017-11-9 · Full Automatic 1.5 Ton Gas Oil Biogas Fired Steam Boiler, Find Complete Details about Full Automatic 1.5 Ton Gas Oil Biogas Fired Steam Boiler,Biogas Fired Steam Boiler,1.5 Ton Oil Boiler,Automatic Gas Boiler from Boilers Supplier or Manufacturer-Henan Province Sitong Boiler Co., Ltd.

Get a Quote

WNS Series Horizontal Fire Tube Steam

Brief Introduction of WNS Series Oil Gas Steam Boiler:. The working principle of the fire tube boiler is based on hot gases of combustion that circulates through a range of pipes surrounded by water. TaiGuo® WNS Series fast assembly fire tube gas oil fired boiler, also known as three pass design boiler or packaged boiler, is a kind of safe, eco-friendly and high efficiency heating equipment

Get a Quote

Oil Steam Boiler on sales of page 4 - Quality Oil Steam

2Ton 4Ton Oil Steam Boiler Safety Operating For Industry Heating Boiler description WNS series gas/oil fired steam boiler is horizontal three pass fire tube wet back full automatic steam boiler. It normally

Get a Quote

Automatic Fire Tube Industrial 1 ton Steam Oil Gas

2020-1-18·Henan Province Sitong Boiler Co., Ltd has over 20 years experience in boilers manufacture, mainly production include oil and gas steam boilers, coal fired steam/hot water boiler, thermal oil heaters, biomass and coal fired thermal oil boiler, electric heating boiler, waste heat boilers, and other configuration vessels.

Get a Quote

Steam Boiler Price 200bhp From China - China 1 Ton

Steam boiler price 200bhp from china. I.General introduction of our gas oil fired steam boiler. WNS series gas/oil fired steam boiler is horizontal three pass fire tube wet back full automatic steam boiler.It normally suitable for 500kg to 20ton/h capacity, use all kinds of gas and oil fuels,such as natural gas, lpg,lng,cng,city gas,biogas, diesel oil,heavy oil.

Get a Quote

Oil Steam Boiler on sales of page 4 - Quality Oil Steam

2Ton 4Ton Oil Steam Boiler Safety Operating For Industry Heating Boiler description WNS series gas/oil fired steam boiler is horizontal three pass fire tube wet back full automatic steam boiler. It normally

Get a Quote

Qingdao East Power Industry Equipment Co., Ltd. -

Qingdao East Power Industry Equipment Co., Ltd., Experts in Manufacturing and Exporting Steam Boiler, Thermal Oil Boiler and 634 more Products. A Verified CN Gold Supplier on Alibaba.com.

Get a Quote

Products_TAIGUO Boiler Company - cnboilers.com

It is a kind of safe and high efficiency heating equipment with full automatic contr Send Inquiry. gas/oil fired condensing Steam Boiler achieves high efficiency greater than 99% or more. which needs labour to feed fuel and remove the dregs. It has fire tube and water tube str Send Inquiry.

Get a Quote

Automatic Wns Steam Boiler - tabernaelbarracon.com

Automatic Wns Oil Gas Fired Steam Boiler. WNS Fire Tube Steam Boiler-yuanda-steamboiler.c. The Introduction of WNS Fire Tube Steam Boiler: WNS fire tube steam boiler is a kind of safe and high efficiency heating equipment from Yuanda with full automatic control system, it can also be named as gas/oil steam boiler, packaged boiler, three pass design boiler and eco-friendly boiler.

Get a Quote

Heating Fuel Steam Atmospheric Pressure Water Tube

Automatic Oil (Fired) Steam Boiler & Water Tube Boiler products . Safety: with water level, leakage steam, steam pressure control. Make sure boiler workin Atmospheric Ho t water boiler This series boiler is horizontal three-return fire tube and w--

Get a Quote

Related Information

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top